Product ID:MIL-C-22750E B COMPONENT ORGANIC COATING, F-09P400
MSDS Date:10/24/1995
FSC:8010
NIIN:01-350-4731
Kit Part:Y
MSDS Number: CBQYP

Emergency Phone: 804-397-2223

Info Phone: 804-397-2223

Cage: 60163

Telephone: 757-397-2223

Cage: 60163

96 @ 20C.

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 25%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM;500 STEL

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:BREATHING OF HIGH VAPOR CONCENTRATIONS
MAY PRODUCE NARCOSIS. LIQUID MAY CAUSE MINOR SKIN IRRITATION &
DEFINITE EYE IRRITATION. CAUSES NOSE & THROAT IRRITATION. CAUSES
EYE & SKIN IRRITATION. REPEATED & PROLONGED OVEREXPOSURE TO
SOLVENTS COULD CAUSE PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
INTENTIONAL (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:MISUSE BY DELIBERATELY CONCENTRATING &
INHALING CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:REMOVE TO FRESH AIR, RESTORE BREATHING. CONSULT MD.
SKIN:FLUSH IMMEDIATELY W/PLENTY OF WATER FOR AT LEAST 15 MINUTES
WHILE REMOVING CONTAMINATED CLOTHING/SHOES. GET IMMEDIATE MEDICAL
ATTENTION. WASH CLOTHING BEFORE REUSE. DESTROY SHOES. EYES:FLUSH
IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES & GET
IMMEDIATE MEDICAL ATTENTION. INGEST:GET MEDICAL ATTENTION
IMMEDIATELY.

Flash Point Method:SCC
Flash Point:63.0F,17.2C
Lower Limits:2%
Upper Limits:12%
Extinguishing Media:ALCOHOL, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CONTAINERS. IF WATER IS USED
FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:FLAMM LIQ - CLASS III. KEEP CNTNRS
TIGHTLY CLSD. VAPS MAY MIGRATE TO IGNIT SOURCE & CAUSE FLASH FIRE.
ISOLATE FROM HEAT, SPKS, ELEC EQUIP, APPLIANCES, (SUPDAT)

Spill Release Procedures:IN CASE OF SPILLAGE ABSORB W/INERT MATERIAL &
DISPOSE OF I/A/W APPLICABLE REGULATIONS OF EPA & OTHER LOCAL, STATE
& FEDERAL AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING.
STORE AWAY FROM HEAT, SPARKS & OPEN FLAME. AVOID PROLONGED SKIN
CONTACT. DO NOT BREATHE SPRAY MIST.
Other Precautions:STORE IN COOL, DRY AREA W/VENT SUITABLE FOR STORING
MATLS SHOWN IN INGS SECTION. GROUND CNTNRS WHILE POURING. AVOID
SPONTANEOUS COMBUST OF CONTAM RAGS/OTHER ORGANIC MATLS. EMPTY
CNTNRS MAY RETAIN HAZ PROPERTIES & CAN BE DANGEROUS.

Respiratory Protection:NIOSH/MSHA APPRVD RESP TYPES SUITABLE FOR MATLS
IN INGS SECTION REC. NIOSH/MSHA APPRVD CHEM/MECH FILTERS REC WHEN
VENT IS RESTRICTED. DO NOT BREATHE (DUST, VAPS/SPRAY MIST). WEAR
APPROP NIOSH/MSHA APP RVD RESP, DURING & AFTER (SUPP DATA)
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAM BELOW CURRENT APPLIC OSHA PEL/ACGIH'S (SUPDAT)
Protective Gloves:CHEM RESISTANT PLASTIC/RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS(SUPDAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . AS REQD TO AVOID WETTING CLTHG, USE (SUPDAT)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE & WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ:PILOT LIGHTS, FLAMES & OTHER SOURCES OF IGNIT. FLAMM LIQ &
VAP. RESP PROT:APPLICATION UNLESS AIR MONITORING RECORDS VAP/MIST
LEVELS BELOW APPLIC LIMS. FOLLOW RESP MFR DIRECTIONS FOR USE. VEN
T:TLV LIM. USE W/ADEQ VENT. EYE PROT:& FULL LGTH FCSHLD . OTHER
PROT EQUIP:PROT CREAMS WHERE SKIN CONT IS LIKELY.

Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:0.97
VOC Pounds/Gallon:236
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID; SOLVENT ODOR.
Percent Volatiles by Volume:30.3

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS OR OPEN FLAME.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
I/A/W LOCAL, COUNTY, STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.